Page 1 of 1
Elite SA50 Main Harness Reference
Posted: Fri Aug 10, 2018 4:25 am
by mousewheels
This thread is an information capture for the connectors, signals and diagrams related to the Main Wire Harness.
First up are photo/diagrams covering the below views:
- On bike view
- Harness connector overview
- Connector wire by wire detail
Re: Elite SA50 Main Harness Reference
Posted: Fri Aug 10, 2018 4:40 am
by mousewheels
Section - On Bike Harness and component view
1) Location - Under Front Cover plastic
- Ign_horn_reg_installed_labeled.jpg (243.54 KiB) Viewed 6243 times
2) Location - Floor under Rear Cover Plastic
- Battery_Area_installed_labeled_sm.jpg (190.37 KiB) Viewed 6243 times
3) Location - Right Rear frame
- Rear_Harness_installed_breakout_labeled_sm.jpg (174.26 KiB) Viewed 6243 times
Re: Elite SA50 Main Harness Reference
Posted: Fri Aug 10, 2018 4:49 am
by mousewheels
Section - Harness Connector Overview
1) Front Harness
- Front_Harnes_Labeled.jpg (145.35 KiB) Viewed 6242 times
2) Middle Harness
- Under_Seat_Connections_labeled.jpg (165.95 KiB) Viewed 6242 times
3) Rear Harness
- Rear_Connections_labeled.jpg (127.34 KiB) Viewed 6242 times
Re: Elite SA50 Main Harness Reference
Posted: Fri Aug 10, 2018 4:58 am
by mousewheels
Section - Connector wire signal detail - UnderFront Cover
These views are helpful in troubleshooting to identify and locate test probe connections to harness
1) Dash Connector - Large 6 pin, 0.25" (6.3mm) contacts
- Headset_large_connector_diagram.jpg (119.52 KiB) Viewed 6241 times
2) Dash Connector - Small 6 pin, 0.110" (2.8mm) contacts
- Headset_small_connector_diagram.jpg (120.42 KiB) Viewed 6241 times
3) Regulator/Rectifier
- Regulator_Conn_with_diagram.jpg (187.67 KiB) Viewed 6241 times
Re: Elite SA50 Main Harness Reference
Posted: Fri Aug 10, 2018 5:03 am
by mousewheels
4) Horn and Bystarter Series Resistor
- Regulator_Horn_Resistor_Diagram.jpg (126.58 KiB) Viewed 6240 times
Re: Elite SA50 Main Harness Reference
Posted: Fri Aug 10, 2018 5:39 am
by mousewheels
Section - Connector wire signal detail - Under Seat Storage
1) Ignition Control Module
- CDI_Conn_with_diagram.jpg (239.26 KiB) Viewed 6238 times
2) Starter Relay
- Starter_Relay Diagram.jpg (198.03 KiB) Viewed 6238 times
3) Stator Connector
- Stator_Connector_labeled.jpg (201.05 KiB) Viewed 6238 times
Re: Elite SA50 Main Harness Reference
Posted: Fri Aug 10, 2018 5:59 am
by mousewheels
Section - Connector wire signal detail - Rear Right Frame
Note: In the photo below, the wires for the ignition coil and oil level switch are not present. An additional photo will be added soon.
- Rear_Light_and_Fuel_diagram.jpg (168.15 KiB) Viewed 6238 times
Re: Elite SA50 Main Harness Reference
Posted: Sun Aug 12, 2018 6:19 pm
by Wheelman-111
Greetings:
Mouse Awesome-ness. If I remember how to make a Tech Doc or a sticky, it's going there for posterior-ity.