Elite SA50 Main Harness Reference

The place to discuss rides, accessories, or whatever is tangentially Spree/Elite-related

Moderator: Moderator

Post Reply
mousewheels
Veteran OG
Veteran OG
Posts: 3639
Joined: Tue May 22, 2007 8:10 pm
Location: North of Seattle, WA

Elite SA50 Main Harness Reference

Post by mousewheels »

This thread is an information capture for the connectors, signals and diagrams related to the Main Wire Harness.

First up are photo/diagrams covering the below views:
  • On bike view
  • Harness connector overview
  • Connector wire by wire detail
mousewheels
Veteran OG
Veteran OG
Posts: 3639
Joined: Tue May 22, 2007 8:10 pm
Location: North of Seattle, WA

Re: Elite SA50 Main Harness Reference

Post by mousewheels »

Section - On Bike Harness and component view


1) Location - Under Front Cover plastic
Ign_horn_reg_installed_labeled.jpg
Ign_horn_reg_installed_labeled.jpg (243.54 KiB) Viewed 6121 times


2) Location - Floor under Rear Cover Plastic
Battery_Area_installed_labeled_sm.jpg
Battery_Area_installed_labeled_sm.jpg (190.37 KiB) Viewed 6121 times


3) Location - Right Rear frame
Rear_Harness_installed_breakout_labeled_sm.jpg
Rear_Harness_installed_breakout_labeled_sm.jpg (174.26 KiB) Viewed 6121 times
mousewheels
Veteran OG
Veteran OG
Posts: 3639
Joined: Tue May 22, 2007 8:10 pm
Location: North of Seattle, WA

Re: Elite SA50 Main Harness Reference

Post by mousewheels »

Section - Harness Connector Overview


1) Front Harness
Front_Harnes_Labeled.jpg
Front_Harnes_Labeled.jpg (145.35 KiB) Viewed 6120 times

2) Middle Harness
Under_Seat_Connections_labeled.jpg
Under_Seat_Connections_labeled.jpg (165.95 KiB) Viewed 6120 times


3) Rear Harness
Rear_Connections_labeled.jpg
Rear_Connections_labeled.jpg (127.34 KiB) Viewed 6120 times
mousewheels
Veteran OG
Veteran OG
Posts: 3639
Joined: Tue May 22, 2007 8:10 pm
Location: North of Seattle, WA

Re: Elite SA50 Main Harness Reference

Post by mousewheels »

Section - Connector wire signal detail - UnderFront Cover


These views are helpful in troubleshooting to identify and locate test probe connections to harness


1) Dash Connector - Large 6 pin, 0.25" (6.3mm) contacts
Headset_large_connector_diagram.jpg
Headset_large_connector_diagram.jpg (119.52 KiB) Viewed 6119 times


2) Dash Connector - Small 6 pin, 0.110" (2.8mm) contacts
Headset_small_connector_diagram.jpg
Headset_small_connector_diagram.jpg (120.42 KiB) Viewed 6119 times


3) Regulator/Rectifier
Regulator_Conn_with_diagram.jpg
Regulator_Conn_with_diagram.jpg (187.67 KiB) Viewed 6119 times
mousewheels
Veteran OG
Veteran OG
Posts: 3639
Joined: Tue May 22, 2007 8:10 pm
Location: North of Seattle, WA

Re: Elite SA50 Main Harness Reference

Post by mousewheels »

4) Horn and Bystarter Series Resistor
Regulator_Horn_Resistor_Diagram.jpg
Regulator_Horn_Resistor_Diagram.jpg (126.58 KiB) Viewed 6118 times
mousewheels
Veteran OG
Veteran OG
Posts: 3639
Joined: Tue May 22, 2007 8:10 pm
Location: North of Seattle, WA

Re: Elite SA50 Main Harness Reference

Post by mousewheels »

Section - Connector wire signal detail - Under Seat Storage

1) Ignition Control Module
CDI_Conn_with_diagram.jpg
CDI_Conn_with_diagram.jpg (239.26 KiB) Viewed 6116 times
2) Starter Relay
Starter_Relay Diagram.jpg
Starter_Relay Diagram.jpg (198.03 KiB) Viewed 6116 times
3) Stator Connector
Stator_Connector_labeled.jpg
Stator_Connector_labeled.jpg (201.05 KiB) Viewed 6116 times
mousewheels
Veteran OG
Veteran OG
Posts: 3639
Joined: Tue May 22, 2007 8:10 pm
Location: North of Seattle, WA

Re: Elite SA50 Main Harness Reference

Post by mousewheels »

Section - Connector wire signal detail - Rear Right Frame
Note: In the photo below, the wires for the ignition coil and oil level switch are not present. An additional photo will be added soon.
Rear_Light_and_Fuel_diagram.jpg
Rear_Light_and_Fuel_diagram.jpg (168.15 KiB) Viewed 6116 times
User avatar
Wheelman-111
Moderator
Moderator
Posts: 11319
Joined: Wed Oct 22, 2008 5:09 pm
Location: Deepinnaharta, Texas

Re: Elite SA50 Main Harness Reference

Post by Wheelman-111 »

Greetings:

Mouse Awesome-ness. If I remember how to make a Tech Doc or a sticky, it's going there for posterior-ity.
Wheelman-111
Most of my money is spent on scooterparts. The rest is just wasted.
"ISO": '03 Vespa ET4 Malossi187 74MPH
Flash 9: 2001 Elite SR Contesta 72 ZX Tran, 9:1 Gears, Stock Airbox/Carb/Pipe 58.8 MPH
Punkin: 2010 Vespa/Malossi S78, 61MPH
Post Reply