Sa50p starts and runs for 30 secs then dies
Moderator: Moderator
-
- BMX
- Posts: 31
- Joined: Sat Aug 04, 2012 1:56 pm
- Location: Staunton, VA
Sa50p starts and runs for 30 secs then dies
My 2000 honda elite sa50p starts and runs for 30 secs then dies, and i cant seem to figure out what the problem is can some1 please help.........
- swimmingfree
- CBR1000RR
- Posts: 3357
- Joined: Tue Jun 14, 2011 12:28 pm
- Location: mich.
Re: Sa50p starts and runs for 30 secs then dies
have you clean the carb ??? id it run before???
swimmingfree
swimmingfree
handicap (dyslexia)
looking for
se50 crank...
SpreJunk 87elite in a spree body
ruckus variator , 3.5 tire , 1500 drive face spring , a 64 bbk ,
8 gram rollers, stock carb , after market air filter and 105 jet
looking for
se50 crank...
SpreJunk 87elite in a spree body
ruckus variator , 3.5 tire , 1500 drive face spring , a 64 bbk ,
8 gram rollers, stock carb , after market air filter and 105 jet
-
- BMX
- Posts: 31
- Joined: Sat Aug 04, 2012 1:56 pm
- Location: Staunton, VA
Re: Sa50p starts and runs for 30 secs then dies
Yes i cleaned the carb twice now....and yes i ran like a champ b4.....i had a piston circlip blow out and messed up cylinder but i got new cylinder, piston, rings n circlips and it was running fine after that...but after month n half or so it started to overheat i think becuz id ride it for 30-45mins and itd bog down and die and would be hot as *....i replaced the oil seal behind the variator and now like i said i start it up itll run for 30secs to a min then bog down n die.....
- swimmingfree
- CBR1000RR
- Posts: 3357
- Joined: Tue Jun 14, 2011 12:28 pm
- Location: mich.
Re: Sa50p starts and runs for 30 secs then dies
is it a stock motor ???? pull the plug and see what color it is .. is the plug wet or dry????? is the carb set to the book ??
swimmingfree
swimmingfree
handicap (dyslexia)
looking for
se50 crank...
SpreJunk 87elite in a spree body
ruckus variator , 3.5 tire , 1500 drive face spring , a 64 bbk ,
8 gram rollers, stock carb , after market air filter and 105 jet
looking for
se50 crank...
SpreJunk 87elite in a spree body
ruckus variator , 3.5 tire , 1500 drive face spring , a 64 bbk ,
8 gram rollers, stock carb , after market air filter and 105 jet
-
- BMX
- Posts: 31
- Joined: Sat Aug 04, 2012 1:56 pm
- Location: Staunton, VA
Re: Sa50p starts and runs for 30 secs then dies
Its a stock motor only thing ive done to it was derestrict it but it ran fine for the longest time....The spark plug is turning slight brown and is slighty wet.....the carb is set by the book air/fuel screw is 1 3/4 -1 7/8 turns..
- swimmingfree
- CBR1000RR
- Posts: 3357
- Joined: Tue Jun 14, 2011 12:28 pm
- Location: mich.
Re: Sa50p starts and runs for 30 secs then dies
did you up jet the carb???? it did not run fine you said it over heated ..... the slide were it the pin set????
swimmingfree
swimmingfree
handicap (dyslexia)
looking for
se50 crank...
SpreJunk 87elite in a spree body
ruckus variator , 3.5 tire , 1500 drive face spring , a 64 bbk ,
8 gram rollers, stock carb , after market air filter and 105 jet
looking for
se50 crank...
SpreJunk 87elite in a spree body
ruckus variator , 3.5 tire , 1500 drive face spring , a 64 bbk ,
8 gram rollers, stock carb , after market air filter and 105 jet
Re: Sa50p starts and runs for 30 secs then dies
check the petcock too it could be running out of gas from the petcock being bad
1986 Spree/ Eve af16 swapped 65cc Prodigy vari 8g 9:1 Ruima gears
21mm OKO 42/100 32:1 45mph kymco zx exhaust
1994 Elite S 17.5mm Arreche, Daytona reeds, SEF ramp, pump plugged
1987 Elite SE50 af16 swapped
1989 Elite E SB50p
2003 Yamaha Zuma
21mm OKO 42/100 32:1 45mph kymco zx exhaust
1994 Elite S 17.5mm Arreche, Daytona reeds, SEF ramp, pump plugged
1987 Elite SE50 af16 swapped
1989 Elite E SB50p
2003 Yamaha Zuma
-
- BMX
- Posts: 31
- Joined: Sat Aug 04, 2012 1:56 pm
- Location: Staunton, VA
Re: Sa50p starts and runs for 30 secs then dies
it was running fine like i said but when the overheating started bout 2-3days is when it started running for 30 secs or so and then bogging down and dying.....I just jetted the carb today replace #68 with #78 and i got it running for bout 3-4mins and then it died down again...i think today it may have been dying down becuz i dont think i got the right air fuel setting for the new air filter i put on it when i upped the jet, do u happen to know how many turns for aftermarket air filter?.....
And what do u mean by the slide were it pin set?...And the peacock is fine i checked it and its flowing fuel good.......
And what do u mean by the slide were it pin set?...And the peacock is fine i checked it and its flowing fuel good.......
- martynkim
- Board Supporter
- Posts: 2899
- Joined: Tue Jan 05, 2010 10:22 pm
- Location: Tacoma, Washington
Re: Sa50p starts and runs for 30 secs then dies
It sounds to me that you could have damaged the bore. I think you need more oil sounds like it is lean. Compression Check?
Need parts? Parting out Spree Aero and Elite!
What people share about buying from me http://www.hondaspree.net/phpBB3/viewto ... =1&t=15559
PM me with your needs Cheap Parts
What people share about buying from me http://www.hondaspree.net/phpBB3/viewto ... =1&t=15559
PM me with your needs Cheap Parts
-
- BMX
- Posts: 31
- Joined: Sat Aug 04, 2012 1:56 pm
- Location: Staunton, VA
Re: Sa50p starts and runs for 30 secs then dies
i got new cylinder jug on it......and how much oil do i premix in gas for unrestricted with 78 jet?.....oh yeah btw do any of yall know how to remove oil pump gear from crankcase without removing crankshaft?
- paulpauly7
- CB900F
- Posts: 1945
- Joined: Tue Feb 21, 2012 6:57 pm
- Location: nz
Re: Sa50p starts and runs for 30 secs then dies
you unbolt the oil pump and the geared shaft comes out with it
86 Nifty Fifty (spree)
ZX disk brake
Kitico 120kmh speedo
AF18 ZX ported
Polini corsa
Malossi crank
CTmani
24mmOKO
40pilot118main
Scorpion pipe
8.44 to 1
Michelin s1
71.3mph
92 yz125, 94 crm250
ZX disk brake
Kitico 120kmh speedo
AF18 ZX ported
Polini corsa
Malossi crank
CTmani
24mmOKO
40pilot118main
Scorpion pipe
8.44 to 1
Michelin s1
71.3mph
92 yz125, 94 crm250
- swimmingfree
- CBR1000RR
- Posts: 3357
- Joined: Tue Jun 14, 2011 12:28 pm
- Location: mich.
Re: Sa50p starts and runs for 30 secs then dies
i wood leve the oil pump in ... when it starts dose it idle???? the slide and pin are the things that is on the gas cable ...
swimmingfree
swimmingfree
handicap (dyslexia)
looking for
se50 crank...
SpreJunk 87elite in a spree body
ruckus variator , 3.5 tire , 1500 drive face spring , a 64 bbk ,
8 gram rollers, stock carb , after market air filter and 105 jet
looking for
se50 crank...
SpreJunk 87elite in a spree body
ruckus variator , 3.5 tire , 1500 drive face spring , a 64 bbk ,
8 gram rollers, stock carb , after market air filter and 105 jet
-
- Elite
- Posts: 722
- Joined: Thu Apr 19, 2007 6:40 pm
- Location: oregon coast
Re: Sa50p starts and runs for 30 secs then dies
Check the plugs color
-
- BMX
- Posts: 31
- Joined: Sat Aug 04, 2012 1:56 pm
- Location: Staunton, VA
Re: Sa50p starts and runs for 30 secs then dies
well i unbolted the oil pump and the gear aint come out with it, thats what i was asking bout it for becuz i need to get the gear out without takin the whole case apart becuz i dont have the flywheel puller for the flywheel on alternator/stator with the woodriff key on it....
-
- BMX
- Posts: 31
- Joined: Sat Aug 04, 2012 1:56 pm
- Location: Staunton, VA
Re: Sa50p starts and runs for 30 secs then dies
swimmingfree- the slide and pin ur talkin bout, do i move it down a notch since i upped the jet becuz it idles high as * and when i turn the throttle its trys to bog down n die? and i already took off the pump so i can replace the crank oil seal behind the variator and the gear shaft is stuck in the case....